Effect of sugarcane pressmud biocompost on

Journal of Biology, Agriculture and Healthcare www.iiste.org
ISSN 2224-3208 (Paper) ISSN 2225-093X (Online)
Vol.4, No.23, 2014
142
Effect of Sugarcane Pressmud Biocompost on Dry Matter Yield
and Nutrient Uptake in Maize
Korai, P.K*, Memon, K.S*, Genxing Pan, Rajper, A.A, Jamro, G.M, Korai, S.K and Jarwar, A.D**
* Sindh Agriculture University,Tando Jam.
** Agriculture Research Institute Tando jam Sindh Pakistan.
Contact information: Institute of Recourses, Ecosystem and Environment of Agriculture, Nanjing agriculture
university, 1 Weigang, Nanjing, 210095-China.
Author: punhoonkorai@gmail.com
Abstract
An experiment was conducted to determine the nutrient contents and manurial value of biocompost,
collected from Matiari Sugar Mill, Matiari and analyzed for macro nutrients N, P and K. The biocompost was
evaluated in a pot experiment on maize crop with eight treatments in factorial combinations of two rates of
biocompost (0 and 10 tons ha-1
) and four fertilizer treatments (0-0-0, 150-0-0, 150-75-0 and 150-75-60 kg ha-1
N,
P and K) . The treatments were replicated three times in a randomized complete block design and maize was
grown for 7 weeks. The soil was a clay loam (31% clay) with EC 0.35 dSm-1
, pH 7.87, low in organic matter
(0.80%) and Olsen P (7.0 mg kg-1
) and high in NH4OAC-K (320 mg kg-1
). The nutrient contents of biocompost
were 1.8% N, 1.83% P and 0.9% K. Results revealed that there were pronounced positive effects of addition of
biocompost, as well as N on plant height and dry weights of maize. Plant analysis data showed that the effect
biocompost and mineral fertilizers was non-significant with respect to N, P and K contents. Soil analytical data
showed that the EC values of post harvest samples increased with the application of biocompost while pH was
not affected. Soil organic matter, Olsen P and NH4OAC-K increased significantly with the application of
biocompost. Fertilizer application also increased Olsen P and NH4OAC-K contents in soil. The results of this
study showed that biocompost can be used along with mineral fertilizers to increase maize growth and dry matter
yield.
Keywords: Maize, Dry matter yield, Pressmud Biocompost;
INTRODUCTION
Generally the soils of Pakistan are deficient in N, whereas 80% soils are deficient in P and 30-40% soils
are also deficient in K. Majority of soils contain <1.0% organic matter. Continuous cropping without application
of organic materials is leading to depletion of available nutrients and organic matter. The situation calls for
integrated use of organic sources of nutrients such as FYM, poultry manure, press mud etc., along with mineral
fertilizer sources.
Among the organic sources of nutrition, pressmud occupies unique position as a by-product of sugar
industry. Pressmud can serve as a good source of organic matter (Bokhtiar et al., 2001), an alternate source of
crop nutrients and soil ameliorant (Razzaq, 2001). It is also known as filter cake or filter mud, and used as
fertilizer in soils (Raman et al., 1999; Barry et al., 2001). It contains much of the colloidal organic matter anions
that precipitate during clarification, as well as certain non-sugar occluded in these precipitates. It is the residue
obtained from sedimentation of the suspended materials such as fiber, sugar, wax, ash, soil and other particles
from the cane juice. The organic fraction of pressmud is 15-30% fiber, 5-15% crude protein, 5-15% sugar, 5-
15% crude wax and fats and 10-20% ash comprising oxides of Si, Ca, P, Mg and K (Partha and
Sivasubramanian, 2006). This organic matter is highly soluble and readily available to the microbial activity and
so to the soil (Gaikwad et al., 1996; Rangaraj et al., 2007).
The weight of wet filter mud (80% water) averages about 3.4% cane. There are many physical, chemical
and biological advantages of pressmud. It improves structure, texture, aeration, water-holding capacity, and
porosity and increases stress tolerance. The yields of various crops including maize and millet showed
substantial increases with pressmud (PM) applications (Rangaraj et al., 2007; Elsayed et al., 2008) that were
attributed to the improvement in soil physical, chemical and biological conditions (Barry et al., 2001).
Maize dry matter yields increased with increasing nitrogen and pressmud rates (Bangar et al., 2000).
Memon (2005) reported that the raw pressmud had depressing effect on dry matter yield of maize, and that the
benefit of previously applied pressmud was evident in the subsequent wheat crop. Viator et al. (2002) reported
that filter cake increases cation exchange capacity for thirty months after its application and its residual effect
remains after four years.
In addition to pressmud, the sugur mills running distillery unit also produce another by product called
“spent wash”. These two by products and fly ash are mixed in a certain ratio and composted for 4-6 weeks before
it is sold as “biocompost” by sugar mills. While pressmud is the basic material used in preparation of
biocompost, spent wash is sprinkled on it during composting process. The resulting “biocompost” is therefore
considered to be rich in nutrients and ready to be applied to soils as a soil amendment.

Vol.4, No.23, 2014
143
Keeping in view the significance of pressmud in the present scenario of agriculture and availability of
nutrients, this study was conducted to determine the value of bio-compost prepared from sugar cane pressmud
using maize as a test crop.
MATERIALS AND METHODS
A pot experiment was conduced in the Ware House of the Department of Soil Science. Bulk
sample of fertile soil (plough layer) was collected from Latif Experimental Farm of Sindh Agriculture University
Tandojam. The soil was air dried and passed through 4 mm garden sieve. Ten kilogram air dried soil was placed
in each of the 24 plastic pots. The experiment was laidout with eight treatments with three replications in a
randomized complete block design (RCBD). The treatments were factorial combination of four rates of mineral
fertilizer and two rates of biocompost. The details of the treatment combinations are as under.
Fertilizer treatments (Four)
Control = No fertilizer applied
N = 150 kg N ha-1
NP = 150 kg N+75 kg P2O5 ha-1
NPK = 150 kg N + 75 P2O5 + 60 kg K2O ha-1
Biocompost tretments (Two)
1. -Biocompost = No biocompost applied
2. +Biocompost = Biocompost at 10 t ha -1
Analysis
Soil sampling
The soil samples were analyzed for some physico-chemical properties by internationally recognized
methods as follows: Soil texture (particle size) by Bouyoucos Hydrometer method as described by Bouyoucos
(1962), EC (dSm-1
) and pH of 1:5 soil water extract by digital Conductivity Meter and digital pH Meter
respectively, organic matter by Walkley-Black method as described by Jackson (1958), available P by Olsen’s
(Olsen’s et al. 1954) NaHCO3 (0.5M, pH 8.5) extraction followed by colour development by ascorbic acid
method as given by Murphy and Riley (1964), and extractable K by extraction with 1N ammonium acetate
followed by analysis of the extract on flame photometer as described by Jackson (1958).
Biocompost and plant
Biocompost used in this study and the plant samples drawn at harvesting from each treatment were
analyzed for total N, P and K. Total N was determined by digestion with concentrated H2SO4 along with a
mixture of selenium, CuSO4 and K2SO4 in 0.1:1:10 ratio using Kjeltech Digestion System 20. The digests were
distilled by using Kjeltech Distillation Unit 1002 as described by Winkleman et al. (1986).
For P and K, the plant samples were digested in 1:5 HClO4: HNO3 mixture followed by analysis of the
digest by vandomolybdophosphoric acid yellow colour method (Barton, 1954) for P and flame photometer for K
(Jackson, 1958).
Data analysis
The data were statistically analysed by using software Statistix 8.1 and the calculations were made using
following formulae.
1. Standard Error for Difference between Means (S.E.D) was calculated using the following formula:
S.E.D = (√2EMS/n) EMS= Error Mean Square.
2. Least Significant Difference (LS.D) = S.E.D x t value for Error df at 5% probability level.
3. Coefficient of Variance (%) = (√MSE / Grand Mean) x 100.
RESULTS AND DISCUSSIONS
Soil properties
The soil used for the experiment was analyzed for some physico-chemical properties (Table 1). The results
revealed that the soil was a clay loam (31% clay) with EC 0.35 dSm-1
, and pH 7.87. It was low in organic matter
(0.80%), and Olsen P (7.0 mg kg-1
), and adequate in NH4OAc – extractable K (320 mg kg-1
).

Vol.4, No.23, 2014
144
Table 1. Physico-chemical properties of the soil used for pot experiment on maize.
Soil property Values
Texture
Sand (%) 26.5
Silt (%) 42.5
Clay (%) 31.0
Textural Class Clay loam
EC (1: 5 soil – water extract) (dS m-1
) 0.35
pH (1:5 soil – water extract) 7.87
Organic matter (%) 0.80
Olsen P (mg kg-1
) 7.0
NH4OAc- extractable K (mg kg-1
) 320
Uptake of N in maize
The data presented on Table 2 showed that there was pronounced positive effect of addition of
biocompost as well as mineral fertilizer treatments on N uptake in maize. Overall, the N uptake ranged from
9.03% to 15.41%. On an average, the N uptake increased by 28.2% from 10.39 to 13.20% with addition of
biocompost. When biocompost was applied alone to unamended soil, the N uptake increased from 9.03% to
12.21%. Similarly the applications of N fertilizer also increased it significantly to 11.38% and to 15.41% when
biocompost was also added. It was noted that there was no effect of P fertilization (NP treatment) on N uptake,
and that the addition of K fertilizer (NPK treatment) showed decline in N uptake. The effect of fertilizer and
biocompost treatments was similar in all combinations, thus the interaction between fertilizer and biocompost
treatments was observed non significant.
Table 2. Effect of biocompost and mineral fertilizer treatments on N uptake in maize.
Fertilizer treatment - Biocompost + Biocomost * Fertilizer Mean
Control 9.03 12.21 10.26b
N 11.38 15.41 13.39a
NP 11.63 13.54 12.59a
NPK 9.53 11.65 10.59b
Biocompost Mean 10.39b 13.20a 10.59
*Biocompost is prepared from sugarcane filtercake and other waste materials of sugarmill, as detailed in
methodology section.
C V% 13.03
S.E 1.53
L.S.D @ 5%
Fertilizer 1.90
Biocompost 1.34
Fertilizer x Biocompost NS
DISCUSSIONS
Recycling of organic wastes of animal and plant origin is being advocated, along with
chemical fertilizers, as a part of integrated plant nutrition management system. Sugarcane filter cake or pressmud
is valued as a soil amendment and an important source of crop nutrients. It is discarded as a solid waste from
sugarmills or used as manure. It is a source of replenishing nutrients in the soil either alone or in combination
with fertilizer to subsidize the input costs (Khattak and Bhatti, 1986, Hussain and Anjum, 1999). Some sugar
mills enrich pressmud and convert it into a product called as “Biocompost”. This is done by composting of
pressmud after adding distillery spent wash and fly ash in a certain ratio and allowing it to compost for 4-6
weeks before the product is sold as “Biocompost”. This study was undertaken to investigate the comparative
value of biocompost and mineral fertilizer in dry matter yield and nutrition of maize.

Vol.4, No.23, 2014
145
Nutrient composition on pressmud
Pressmud sample from Matiari Sugar Mills of Sindh revealed that it contained sufficient amount of
nutrients for application as soil amendment. Average values of total N, P and K contents were 1.8% N, 1.83% P
and 0.9% K. Many workers have reported the nutrient composition of pressmud. Ibrahim et al. (1999) collected
pressmud samples from five sugarmills of Punjab province of Pakistan and observed variable proportion of plant
nutrients from one mill to another. The values ranged from 1.7-2.3, 1.0-1.3 and 0.6-0.8 % N, P and K
respectively. Besides this, pressmud also contained sufficient amount of micronutrients, which ranged from 58-
71, 4750-5904, 249-330, and 143-220 mg kg-1
Cu, Fe, Mn and Zn respectively.
In one study, Memon (2005) collected sample of pressmud from twenty-one sugarmills of
Sindh and analyzed for macro and micronutrient contents. The analytical data showed that the values ranged
from 1.38-2.29%, 1.29-1.90%, and 0.62-1.98% for total N, P and K respectively and reported that the nutrient
contents of pressmud were not only variable from one mill to the other, but also when the samples were taken at
different times from the same mill. The value for N, P and K contents of the biocompost obtained in this study
fall within the range of the values.
Pot experiment on maize
The results of pot study on maize showed that there was pronounced positive effect of addition
of biocompost on plant height and dry weights. Similarly, addition of fertilizer, particularly N, increased plant
height and dry weights. However, similar study conducted by Memon (2005) revealed that their were
pronounced positive effects of addition of fertilizers, particularly nitrogen on plant height and dry weights, and
depressing effect of pressmud (5 t ha-1
) on maize growth and dry matter. However increase from 5 to 15 tons ha-1
slightly improved the growth and yield performance of maize. Drastic decline in maize dry matter yield was
observed when the rate of pressmud was increased from 15 to 25 tons ha-1
. Plant analysis data revealed
significant increase in N contents with the application of N fertilizer but P and K fertilization and pressmud did
not significantly influence the N contents. It was hypothesized that the initial depressing effect of pressmud was
related to presence of unrecompensed organic matter and the high rates of pressmud. Thus the benefit of
pressmud was observed in a follow up experiment on wheat involving same soil and previously applied
pressmud. These data therefore show that pressmud could be used in the fields for increasing crop production.
However, it was observed that the pressmud also contains large proportion of organic matter,
which upon incorporation in soil undergoes the process of decomposition coupled with enhanced microbial
activity. Being exothermic in nature, and having grown maize in plastic pots exposed to solar radiation, it
resulted in negative effects on plant growth. These finding are also correlated with the finding by Hamdard et al.
(2004) who conducted series of field experiments for evaluating the filtercake, a sugar industry waste, as a plant
nutrition source alone was well as in various combinations with chemical fertilizers in maize-wheat cropping
system. Pooled analysis of three years data showed that maximum wheat grain yield 4.65 tons ha-1
was obtained
where all NP was applied in the form of chemical fertilizers and closely followed by where 25 and 50% NP was
applied in the form of filtercake giving grain yield 4.40 and 4.33 tons ha-1
, respectively. The use of filtercake
increased NP contents in wheat grain but were statistically at par with chemical fertilizers. In case of maize,
filtercake improved NPK contents in maize fodder over control but these were relatively lower than chemical
fertilizer. Pooled soil analysis data revealed that combined use of filtercake and chemical fertilizers also
increased NPK contents and improved organic matter status of the soil. Thus for the judicious use of filtercake it
can be applied up to 50% on nutrient basis, preferably 25% with chemical fertilizers for sustainable agriculture.
Results also revealed that addition of biocompost contributed to improvement in soil properties
including organic matter, and available P and K contents. Such beneficial effect of pressmud, and thus
biocompost, has been reported in many studies. Juwarkar et al. (1993) conducted studies to optimise application
of pressmud along with fertilizer on clay soil for maximizing the production of jowar, wheat, moong and
sugarcane crops and evaluating residual effect of pressmud on crop growth. Application of 20 t/ha pressmud and
addition of NPK equivalent to 75% of recommended dose to each crop through fertilizers were found to be
beneficial and gave 21-43% higher crop yield. Residual effect of pressmud continued upto 3 years and 15-31%
higher crop yield was obtained even in third year with the addition of only 75% of recommended nutrients
through fertilizers. Pressmud application to soil helped to improve the infiltration rate from 4.7 to 5.6 cm per
day. There was no appreciable change in soil pH but organic matter, available P and K increased significantly
over control. In one study Aziz et al. (2010) evaluated the beneficial effects of different sources of organic
manures on soil physico-chemical properties and growth of maize. Organic manures viz. farm yard manure,
poultry manure and pressmud were added in soil filled earthen pots at 10 t ha-1
. Results revealed that organic
matter content, phosphorus and potassium bioavailability in soil and their uptake by plants were increased by
organic manure application irrespective of the source. Likewise organic manure substantially improved the plant
height, leaf area and shoots and root fresh and dry weights. Similarly shoot phosphorus and potassium contents
were also improved by the application of organic manures. This improved growth was mainly due to increased

Vol.4, No.23, 2014
146
soil nutrient availability and uptake by plants. Comparing different sources, phosphorus and potassium
concentration in plants were maximum in poultry manure treatment and farm yard manure, respectively.
LITERATURE CITED
Aziz, T., S. Ullah, A. Sattar, M. Nasim, M. Farooq and M.M. Khan. 2010. Nutrient availability and maize (Zea
mays L.) growth in soil amended with organic manures. Int. J. Agric. Biol., 12: 621–624.
Bangar, K.S., B.B. Parmar and A. Maini. 2000. Effect of nitrogen and pressmud application on yield and uptake
of N, P and K by sugarcane (Saccharum officinarum L.). Crop Research (Hisar), 19(2): 198-203.
Barry, G.A., G.E. Rayment, A.J. Jeffery and A.M. Price. 2001. Changes in cane soil properties from application
of sugar mill by-products. p. 185-199. In: Proceeding Conference of the Australian Society of Sugarcane
Technology, Mackay, Queensland, Australia.
Elsayed, M.T., M.H. Babiker, M.E. Abdelmalik, O.N. Mukhtar and D. Montange. 2008. Impact of filter mud
application on the germination of sugarcane and small-seeded plants and on soil and sugarcane nitrogen
contents. Bioresource Technology 99:4164-4168.
Gaikwad, S.S., R.B. Puranik and S.D. Deshmukh. 1996. Dynamics of soil microbial population and nutrient
availability as influenced by application of pressmud cake in an Entisol. Journal of Soils and Crops 6(1):
82-85.
Hussain, T. and S. Anjum. 1999. Role of biofertilizer in boosting agriculture. Daily Dawn. Economics and
Business Review. October 4-10. p.3.
Hamdard, M.S., A. Sattar and U. Farooq. 2004. Studies on the use of Filtercake as a source of NP for increasing
crop production and its effects on crop quality. In: Proc. Of 10th
Congress Of Soil science held at Sindh
Agriculture University Tando Jam. March 16-19, 2004.pp. 75.
Ibrahim, M. A. Rashid, A.S. Munir. 1999. use of sugar industry by-Product (pressmud) at the national Seminar
on Sugarcane Production held at Ayub Agriculture Research Institute, Faisalabad, Jan. 21-22, 1999.
Juwarkar, A.S., P.B. Deshbhratar, S.A. Bal, and A. Shende. 1993. Pressmud application to soil effect on soil and
crops. J. Ind. Po11.Cont. 9 (1):21-26.
Memon, S. 2005. Effect of pressmud on the growth, yield and chemical composition of maize. M.Sc. Thesis,
Department of Soil Science, Sindh Agriculture University Tandojam, Pakistan.
Partha, N. and V. Sivasubramanian. 2006. Recovery of chemicals from pressmud- A sugar industry waste. Indian
Chemical Engineering Section 48(3): 160-163.
Razzaq, A. 2001. Assessing sugarcane filter cake as crop nutrients and soil health ameliorant. Pak. Sug. J., 21(3):
15-18.
Viator, R.P., J.L. Kovar and W.B. Hallmark. 2002. Gypsum and compost effects on sugarcane root growth,
yield, and plant nutrients. Agron. J. 94: 1332-1336.

Business, Economics, Finance and Management Journals PAPER SUBMISSION EMAIL
European Journal of Business and Management EJBM@iiste.org
Research Journal of Finance and Accounting RJFA@iiste.org
Journal of Economics and Sustainable Development JESD@iiste.org
Information and Knowledge Management IKM@iiste.org
Journal of Developing Country Studies DCS@iiste.org
Industrial Engineering Letters IEL@iiste.org
Physical Sciences, Mathematics and Chemistry Journals PAPER SUBMISSION EMAIL
Journal of Natural Sciences Research JNSR@iiste.org
Journal of Chemistry and Materials Research CMR@iiste.org
Journal of Mathematical Theory and Modeling MTM@iiste.org
Advances in Physics Theories and Applications APTA@iiste.org
Chemical and Process Engineering Research CPER@iiste.org
Engineering, Technology and Systems Journals PAPER SUBMISSION EMAIL
Computer Engineering and Intelligent Systems CEIS@iiste.org
Innovative Systems Design and Engineering ISDE@iiste.org
Journal of Energy Technologies and Policy JETP@iiste.org
Information and Knowledge Management IKM@iiste.org
Journal of Control Theory and Informatics CTI@iiste.org
Journal of Information Engineering and Applications JIEA@iiste.org
Industrial Engineering Letters IEL@iiste.org
Journal of Network and Complex Systems NCS@iiste.org
Environment, Civil, Materials Sciences Journals PAPER SUBMISSION EMAIL
Journal of Environment and Earth Science JEES@iiste.org
Journal of Civil and Environmental Research CER@iiste.org
Life Science, Food and Medical Sciences PAPER SUBMISSION EMAIL
Advances in Life Science and Technology ALST@iiste.org
Journal of Biology, Agriculture and Healthcare JBAH@iiste.org
Journal of Food Science and Quality Management FSQM@iiste.org
Journal of Chemistry and Materials Research CMR@iiste.org
Education, and other Social Sciences PAPER SUBMISSION EMAIL
Journal of Education and Practice JEP@iiste.org
Journal of Law, Policy and Globalization JLPG@iiste.org
Journal of New Media and Mass Communication NMMC@iiste.org
Journal of Energy Technologies and Policy JETP@iiste.org
Historical Research Letter HRL@iiste.org
Public Policy and Administration Research PPAR@iiste.org
International Affairs and Global Strategy IAGS@iiste.org
Research on Humanities and Social Sciences RHSS@iiste.org
Journal of Developing Country Studies DCS@iiste.org
Journal of Arts and Design Studies ADS@iiste.org

The IISTE is a pioneer in the Open-Access hosting service and academic event management.
The aim of the firm is Accelerating Global Knowledge Sharing.
More information about the firm can be found on the homepage:
http://www.iiste.org
CALL FOR JOURNAL PAPERS
There are more than 30 peer-reviewed academic journals hosted under the hosting platform.
Prospective authors of journals can find the submission instruction on the following
page: http://www.iiste.org/journals/ All the journals articles are available online to the
readers all over the world without financial, legal, or technical barriers other than those
inseparable from gaining access to the internet itself. Paper version of the journals is also
available upon request of readers and authors.
MORE RESOURCES
Book publication information: http://www.iiste.org/book/
IISTE Knowledge Sharing Partners
EBSCO, Index Copernicus, Ulrich's Periodicals Directory, JournalTOCS, PKP Open
Archives Harvester, Bielefeld Academic Search Engine, Elektronische Zeitschriftenbibliothek
EZB, Open J-Gate, OCLC WorldCat, Universe Digtial Library , NewJour, Google Scholar

Effect of sugarcane pressmud biocompost on

More Related Content

What's hot (20)

Viewers also liked (12)

Similar to Effect of sugarcane pressmud biocompost on (20)

More from Alexander Decker (20)

Effect of sugarcane pressmud biocompost on